Second-Generation Bioethanol Production Using Hydrolytic Treatment of Durian Seed

Aulia Djati Pramiesta (Department of Mechanical Engineering, Faculty of Engineering and Technology, Sampoerna University, 12780, Jakarta, Indonesia)
H.C. Theofany (Department of Metallurgical and Materials Engineering, Faculty of Engineering, Universitas Indonesia, Depok 16424, Indonesia)
Naurah Rizki Fajrini (Department of Mechanical Engineering, Faculty of Engineering and Technology, Sampoerna University, 12780, Jakarta, Indonesia Department of Environmental Engineering, Faculty of Civil and Environmental Engineering, Institut Teknologi Bandung, 40132, )
H.B. Aditiya (Department of Mechanical Engineering, Faculty of Engineering and Technology, Sampoerna University, 12780, Jakarta, Indonesia Energy Research Center, Faculty of Engineering and Technology, Sampoerna University, Jakarta, Indonesia)
Teuku Meurah Indra Riayatsyah (Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, Faculty of Engineering and Information Technology, University of Technology Sydney, NSW, 2007, Australia Program Study of Mechanical Engineering, Departmen)

Sustainable in Energy Science and Technology
Vol. 1 No. 1 (2025): Sustainable in Energy and Science Technology

Second-generation bioethanol produced from non-edible feedstocks and agricultural waste is a promising alternative to fossil fuels. In this study, durian (Durio zibethinus) seeds – an abundant fruit waste in Indonesia (over 1.14 million tons of durian fruit produced in 2018) – were utilized as a starch-rich feedstock for bioethanol. A microwave-assisted alkaline hydrolysis method was applied and optimized to release fermentable sugars for subsequent bioethanol production. A Box–Behnken experimental design was used to examine the effects of four parameters: NaOH concentration (0.5–1.0 M), durian seed loading (2–4 g/100 mL), microwave irradiation time (2–4 min), and microwave power (200–400 W). Reducing sugar yield (glucose equivalent) was quantified by the dinitrosalicylic acid (DNS) method. The maximum reducing sugar concentration achieved was 2.256 g/L, corresponding to a theoretical ethanol yield of approximately 1.305 g/L. The optimum condition was observed at 4 g durian seed loading, 1 M NaOH, 400 W microwave power, and 4 min irradiation. Regression analysis indicated that microwave power and time had the most significant positive effects on sugar yield, while substrate loading had a moderate effect and alkali concentration the least. These results demonstrate the viability of durian seed waste as a feedstock for bioethanol and provide an optimized set of hydrolysis conditions. However, due to experimental constraints, fermentation of the hydrolysate was not performed; instead, theoretical ethanol yield was calculated. Future work should integrate an actual fermentation step to confirm ethanol production.