Garuda - Garba Rujukan Digital

Akbar, Fazhar

Unknown Affiliation

Author-ID : 1457960

Agriculture, Biological Sciences & Forestry Environmental Science

Published : 3 Documents Claim Missing Document

Claim Missing Document

Articles

Pemanfaatan Limbah Spent Bleaching Earth pada Stabilisasi Tanah Lempung dengan Clean Set Cement Sumarno, Agung; Prasetyo, Agus Mudo; Akbar, Fazhar; Widodo, Eko; Triastuti, Triastuti; Maidina, Maidina; Nugroho, Ananto; Budiman, Ismail; Subiyanto, Bambang
Jurnal Teknologi Lingkungan Vol. 22 No. 1 (2021)
Publisher : Center for Environmental Technology - Agency for Assessment and Application of Technology

ABSTRACT The utilization of waste as soil stabilization materials is a solution to reduce the amount of waste and improve the building materials quality. This research is using Spent Bleaching Earth (SBE) materials from the palm oil industry waste. SBE can be reused to be pozzolan materials. This research aimed to investigate the SBE waste effect as an admixture on clay stabilization used 10% Clean Set Cements (CS-60) on density and California Bearing Ratio (CBR). A combination of CS-60 and SBE waste was expected to increase the CBR value of clay. Furthermore, SBE waste would decrease cementitious material for clay stabilization. Variation comparison of Clay : CS-60 : SBE on ST03, ST04, and ST05 were 67.5% : 10% : 22.5%; 45% : 10% : 45% and 22.5% : 10% : 67.5% respectively. The test was conducted on water content, density, and load penetration based on SNI 1744:2012. Generally, the CBR value of subgrade and improved subgrades oil with the moderate and good category are about 5-20%. As a result, the CBR value of ST 01 as original clay and ST 02 as clay with 10% CS-60 was 3.24% and 5.01%, respectively. Using SBE waste as an admixture material on clay stabilization increased CBR value better than clay stabilization used CS-60. ST03, ST04, and ST05 with CBR's value were 5.39%, 8.52%, and 17.99%, respectively. Furthermore, the density value decreased when SBE waste is used. Keywords : california bearing ratio, clay, clean set cement, spent bleaching earth, stabilization. Â ABSTRAK Pemanfaatan limbah sebagai bahan stabilisasi tanah lempung merupakan solusi dalam mengurangi jumlah limbah dan meningkatkan mutu dari bahan bangunan. Penelitian ini menggunakan material Spent Bleaching Earth (SBE) dari limbah industri pengolahan minyak kelapa sawit. SBE dapat dimanfaatkan sebagai material pozzolan. Penelitian ini bertujuan untuk mengetahui pengaruh limbah SBE sebagai bahan tambah pada stabilisasi tanah lempung yang menggunakan 10% Clean Set Cements (CS-60) terhadap densitas dan California Bearing Ratio (CBR). Kombinasi limbah SBE dengan CS-60 diharapkan mampu meningkatkan nilai CBR tanah lempung. Selain itu, juga mengurangi penggunaan bahan berbasis semen untuk stabilisasi tanah lempung. Variasi perbandingan tanah lempung : CS-60 : SBE yang digunakan pada sampel ST03, ST04, dan ST05 berturut-turut 67,5% : 10% : 22,5%, 45% : 10% : 45% dan 22,5% : 10% : 67,5%. Pengujian yang dilakukan meliputi pengujian kadar air, densitas, dan penetrasi beban yang mengacu pada SNI 1744:2012. Secara umum, nilai CBR tanah dasar dan tanah timbunan dengan kategori sedang dan baik berkisar antara 5-20%. Hasil penelitian ini memperlihatkan bahwa sampel ST01 yang berupa tanah lempung asli memiliki nilai CBR 3,24% dan sampel ST02 yang berupa tanah lempung yang distabilisasi dengan 10% CS-60 menghasilkan nilai CBR 5,01%. Penambahan limbah SBE dapat meningkatkan nilai CBR dengan nilai yang lebih tinggi bila dibanding dengan hanya distabilisasi dengan CS-60, hal ini terlihat pada sampel ST03, ST04, dan ST05 dengan nilai CBR berurutan sebesar 5,39%, 8,52%, dan 17,99%. Selain itu, penambahan limbah SBE juga akan menurunkan densitas dari tanah lempung. Â Kata kunci : california bearing ratio, clean set cement, spent bleaching earth, stabilisasi, tanah lempung.

Pemanfaatan Limbah Spent Bleaching Earth pada Stabilisasi Tanah Lempung dengan Clean Set Cement Sumarno, Agung; Prasetyo, Agus Mudo; Akbar, Fazhar; Widodo, Eko; Triastuti, Triastuti; Maidina, Maidina; Nugroho, Ananto; Budiman, Ismail; Subiyanto, Bambang
Jurnal Teknologi Lingkungan Vol. 22 No. 1 (2021)
Publisher : Center for Environmental Technology - Agency for Assessment and Application of Technology

ABSTRACT The utilization of waste as soil stabilization materials is a solution to reduce the amount of waste and improve the building materials quality. This research is using Spent Bleaching Earth (SBE) materials from the palm oil industry waste. SBE can be reused to be pozzolan materials. This research aimed to investigate the SBE waste effect as an admixture on clay stabilization used 10% Clean Set Cements (CS-60) on density and California Bearing Ratio (CBR). A combination of CS-60 and SBE waste was expected to increase the CBR value of clay. Furthermore, SBE waste would decrease cementitious material for clay stabilization. Variation comparison of Clay : CS-60 : SBE on ST03, ST04, and ST05 were 67.5% : 10% : 22.5%; 45% : 10% : 45% and 22.5% : 10% : 67.5% respectively. The test was conducted on water content, density, and load penetration based on SNI 1744:2012. Generally, the CBR value of subgrade and improved subgrades oil with the moderate and good category are about 5-20%. As a result, the CBR value of ST 01 as original clay and ST 02 as clay with 10% CS-60 was 3.24% and 5.01%, respectively. Using SBE waste as an admixture material on clay stabilization increased CBR value better than clay stabilization used CS-60. ST03, ST04, and ST05 with CBR's value were 5.39%, 8.52%, and 17.99%, respectively. Furthermore, the density value decreased when SBE waste is used. Keywords : california bearing ratio, clay, clean set cement, spent bleaching earth, stabilization. Â ABSTRAK Pemanfaatan limbah sebagai bahan stabilisasi tanah lempung merupakan solusi dalam mengurangi jumlah limbah dan meningkatkan mutu dari bahan bangunan. Penelitian ini menggunakan material Spent Bleaching Earth (SBE) dari limbah industri pengolahan minyak kelapa sawit. SBE dapat dimanfaatkan sebagai material pozzolan. Penelitian ini bertujuan untuk mengetahui pengaruh limbah SBE sebagai bahan tambah pada stabilisasi tanah lempung yang menggunakan 10% Clean Set Cements (CS-60) terhadap densitas dan California Bearing Ratio (CBR). Kombinasi limbah SBE dengan CS-60 diharapkan mampu meningkatkan nilai CBR tanah lempung. Selain itu, juga mengurangi penggunaan bahan berbasis semen untuk stabilisasi tanah lempung. Variasi perbandingan tanah lempung : CS-60 : SBE yang digunakan pada sampel ST03, ST04, dan ST05 berturut-turut 67,5% : 10% : 22,5%, 45% : 10% : 45% dan 22,5% : 10% : 67,5%. Pengujian yang dilakukan meliputi pengujian kadar air, densitas, dan penetrasi beban yang mengacu pada SNI 1744:2012. Secara umum, nilai CBR tanah dasar dan tanah timbunan dengan kategori sedang dan baik berkisar antara 5-20%. Hasil penelitian ini memperlihatkan bahwa sampel ST01 yang berupa tanah lempung asli memiliki nilai CBR 3,24% dan sampel ST02 yang berupa tanah lempung yang distabilisasi dengan 10% CS-60 menghasilkan nilai CBR 5,01%. Penambahan limbah SBE dapat meningkatkan nilai CBR dengan nilai yang lebih tinggi bila dibanding dengan hanya distabilisasi dengan CS-60, hal ini terlihat pada sampel ST03, ST04, dan ST05 dengan nilai CBR berurutan sebesar 5,39%, 8,52%, dan 17,99%. Selain itu, penambahan limbah SBE juga akan menurunkan densitas dari tanah lempung. Â Kata kunci : california bearing ratio, clean set cement, spent bleaching earth, stabilisasi, tanah lempung.

BENDING STRENGTH OF LIGNOCELLULOSIC MATERIALS IN SOFTENING CONDITION Dwianto, Wahyu; Damayanti, Ratih; Darmawan, Teguh; Sejati, Prabu Satria; Akbar, Fazhar; Adi, Danang Sudarwoko; Bahanawan, Adik; Amin, Yusup; Triwibowo, Dimas
Indonesian Journal of Forestry Research Vol. 7 No. 1 (2020): Indonesian Journal of Forestry Research
Publisher : Association of Indonesian Forestry and Environment Researchers and Technicians

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.59465/ijfr.2020.7.1.59-70

This research aimed to understand the softening behaviour and viscoelastic property of wood, rattan, and bamboo as lignocellulosic materials. Nine years-old fast growing teak wood [Tectona grandis L.f.], rattan [Calamus sp.], and 3 years-old andong bamboo [Gigantochloa pseudoarundinaceae (Steud.) Widjaja] were used for the experiments. The samples were taken from the bottom, middle and upper parts for wood and rattan, and that for bamboo were cut from the 1st to 20th internodes. Static bending tests were carried out in fresh (green) as control samples, air-dried, and softened by microwave heating (MW) for 1 min to determine modulus of rupture (MOR) and modulus of elasticity (MOE). The results showed that the MOR and MOE values of wood, rattan, and bamboo increased from fresh to air-dried condition, and decreased by MW. When compared at the same density, drastic increase was observed for the normalized MOR value in air-dried of rattan, i.e. 2.5 fold. However, the decreasing of all the normalized MOR values were almost the same, i.e. 0.5 fold when they were softened by MW. Remarkably increase was also appeared for the normalized MOE value in air-dried of rattan, i.e. 3.0 fold and decreased to almost zero by MW. These results indicated that rattan was more easily bent, followed by bamboo and then wood. Hydrothermal properties of chemical components significantly affected the changes of strength (MOR) and elastic properties (MOE). However, the differences in bending strength of wood, rattan, and bamboo were more likely due to differences in their anatomical structures.

Title

Found 3 Documents
Search

Abstract

Abstract

Abstract

Title Search

Found 3 Documents Search

Abstract

Abstract

Abstract

Title

Found 3 Documents
Search