Garuda - Garba Rujukan Digital

Isolasi dan mikroenkapsulasi vitamin E dari crude palm oil sebagai sumber antioksidan bahan pangan Isolation and microencapsulation of vitamin E from crude palm oil as source of food antioxidant Irma KRESNAWATY; Asmini BUDIANI; . TRI-PANJI; . SUHARYANTO
Menara Perkebunan Vol. 80 No. 2: 80 (2), 2012
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v80i2.38

AbstractIn order to increase value added and to support downstream industry of palm oil, minor components of the oil such as β-carotene and vitamin E should be utilized. Vitamin E is a high value vitamin that could be used as material for pharmaceutical and neutraceutical products. Technological constraints encountered in the utilization of vitamin E from CPO are lack of optimal extraction and purification method as well as the way to stabilize of the product. The research was conducted to find optimal extraction and purification method of vitamin E from CPO and microencapsulation method of vitamin E as pharmaceutical and neutraceutical product. The research showed that vitamin E could be recovered from CPO by several steps process including saponification using NaOH, separation of unsaponificated solution, followed by dissolution using 2-propanol in hexane and extraction using methanol. Raw extract of vitamin E was then purified by coloumn chromatography with stationary phase of silica gel and mobile phase (eluent) of petroleum benzene/ diethyl ether/acetic acid 70 : 30 : 0,2. Purified vitamin E could be collected as fraction 4-8. Vitamin E obtained had similar antioxidant activity as in pure vitamin E (Sigma) and vitamin C. Microencapsulation method could be conducted using arabic gum as coating material followed by spray drying and resulted IC50-DPPH value 132.55 ppm which considered middle activity category.AbstrakUntuk meningkatkan nilai tambah dan mengem-bangkan industri hilir minyak kelapa sawit (CPO), komponen minor minyak tersebut seperti vitamin E dan β-karoten perlu dimanfaatkan. Vitamin E merupakan produk bernilai ekonomis tinggi sebagai bahan farmaseutikal dan neutrasetikal. Kendala yang dihadapi dalam pemanfaatan vitamin E dari CPO, yaitu belum tersedianya teknik ekstraksi dan purifikasi yang optimal dan cara memper-tahankan stabilitas vitamin E. Penelitian ini bertujuan untuk memperoleh teknik ekstraksi dan purifikasi vitamin E dari CPO dan teknik mikroenkapsulasi vitamin E sebagai bahan farmaseutikal dan neutrasetikal. Hasil penelitian menunjukkan bahwa vitamin E dapat diproduksi dengan beberapa tahapan yakni saponifikasi dengan NaOH, pemisahan lapisan pekat tak tersabunkan, pelarutan dengan2-propanol dalam heksana, ekstraksi dengan metanol dan pelarutan ekstrak dengan 2-propanol dalam heksana. Ekstrak kasar vitamin E dimurnikan dengan kromatografi kolom dengan fasa diam silika gel dan fasa gerak petroleum benzen/dietil eter/asam asetat = 70 : 30 : 0,2. Vitamin E dapat dimurnikan pada fraksi ke-4 sampai dengan ke-8. Aktivitas antioksidan vitamin E hasil ekstraksi tersebut setara dengan vitamin E murni (Sigma). Teknik mikroenkapsulasi vitamin E hasil ekstraksi dari CPO dapat dilakukan dengan penyalut gum arab dan pengeringan dengan spray dryer yang menghasilkan anti-oksidan dengan aktivitas IC50 DPPH = 132,55 ppm yang termasuk kategori beraktivitas sedang.

Dinamika populasi Trichoderma harzianum DT38 pada campuran arang hayati tandan kosong kelapa sawit (TKKS) dan gambut Population dinamic of Trichoderma harzianum DT38 on mixture of empty fruit bunches of oil palm (EFBOP) biochar and peat Irma KRESNAWATY; Sayhas SUHADA; Asmini BUDIANI; T W DARMONO
Menara Perkebunan Vol. 80 No. 1: 80 (1), 2012
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v80i1.45

Abstract Biochar offers option for managing land as a source of carbon and soil conditioner. The ability of biochar in increasing soil fertility associates with its ability to retain water, reduce soil acidity, and keep the availability of essential nutrients for plant thus increasing crop produc-tivity, and reducing the risk of soil erosion. Biochar is also substance to provide a suitable environment for the growth of beneficial microbes, including an isolate of Trichoderma harzianum used in this study, that has been proven capable in stimulating plant growth and suppressing soil borne diseases. The purpose of this research was to determine the in vitro compatibility of T. harzianum DT38, Indonesia Biotech-nology Research Institute for Estate Crop (IBRIEC) collection, in mixtures of EFBPO biochar and peat during 28 days. This research was performed in completely randomized design with single factor, comprising of five formulas: 1) 100% EFBOP biochar (K1), 2) 100% peat (K2), 3) Mixture of EFBOP biochar and peat = 1 : 4 (F1), 4) Mixture of EFBOP biochar and peat= 1 : 8 (F2), dan 5) Mixture of EFBOP biochar and peat= 1 : 12 (F3). The colony forming units were determined after storage to express the amount of fungal propaguls in each mixture. The results was analized using one-way ANOVA test and Duncan Test. Result showed that the total of T. harzianum DT38 propaguls was not significantly difference among five mixture preparations tested during 0 and 7 days storage. The total propaguls were insignificantly difference between F1 and K2, and also between F2 and F3in 14, 21 and 28 days incubation. Peat addition on biochar increased the total of T. harzianum DT38 propaguls during 28 days incubation. The total propaguls which are remain high in F1, F2 and F3 formula up to 28 days storage indicating that the mixtures suitable for microbe media and biofertilizer formula.Abstrak Penggunaan arang hayati (biochar) merupakan alternatif pengelolaan tanah terutama sebagai penyedia karbon dan pembenah tanah. Kemampuan biochar dalam meningkatkan kesuburan tanah berhubungan dengan kemampuannya untuk menahan air, mengurangi keasaman tanah, menjaga keter-sediaan nutrien yang penting bagi tanaman sehingga mening-katkan produktivitas tanaman, serta mengurangi resiko erosi tanah. Arang hayati juga berperan dalam menyediakan ling-kungan yang cocok untuk pertumbuhan mikroba, ter-masuk isolat Trichoderma harzianum yang digunakan dalam penelitian ini dan teruji mampu meningkatkan pertumbuhan tanaman dan mengendalikan penyakit tular tanah. Tujuan penelitian ini untuk mengetahui kompatibilitas T. harzianum DT38 koleksi BPBPI pada bahan pembawa berupa campuran biochar tandan kosong kelapa sawit (TKKS) dan gambut selama penyimpanan 28 hari secara in vitro. Penelitian ini menggunakan rancangan acak lengkap (RAL) untuk menguji lima perlakuan, yaitu : 1) 100% biochar TKKS (K1), 2) 100% gambut (K2), 3) Campuran biochar TKKS dan gambut 1 : 4 (F1), 4) Campuran biochar TKKS dan gambut 1 : 8 (F2), dan 5) Campuran biochar TKKS dan gambut 1 : 12 (F3). Hasil pengamatan pada penyimpanan 0 dan 7 hari menunjukkan bahwa jumlah propagul T. harzianum DT38 dari berbagai formula tidak berbeda nyata. Jumlah propagul antara formula F1 dan K2, serta F2 dan F3 tidak berbeda nyata pada penyim-panan 14, 21 dan 28 hari. Penambahan gambut pada biochar TKKS dapat meningkatkan jumlah propagul T. harzianum DT 38 selama penyimpanan 28 hari secara in vitro. Jumlah propagul T. harzianum DT38 pada media F1, F2 dan F3 selama penyimpanan 28 hari masih memenuhi jumlah minimal propagul dalam bahan pembawa yang menunjukkan bahwa media ini sesuai untuk pertumbuhan mikroba dan berpotensi sebagai formula pupuk hayati.

Aplikasi biokaolin untuk perlindungan buah kakao dari serangan PBK, Helopeltis spp. dan Phytophthora palmivora Application of biokaolin in protecting cocoa pod from cocoa pod borer, Helopeltis spp. and Phytophthora palmivora infestation Irma KRESNAWATY; Asmini BUDIANI; Abdul WAHAB; T W DARMONO
Menara Perkebunan Vol. 78 No. 1: 78 (1), 2010
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v78i1.77

AbstractMain constraints of cacao cultivation are infestations of cocoa pod borer (Conopomorpha cramerella (Snellen), Helopeltis spp., and cocoa pod rot disease (palmivora). So far there is no technology that could efficiently controlthese important pests. This research was aimed to develop environmentally friendly new technology to protect pod surfaces of cacao. The experiment was performed in heavily infested cacao plantation in Konawe, South-East Sulawesi.The use of kaolin particle film enriched with entomopathogenic microbe was contrasted againts the use of currently recommended plastic sleeve. Cacao pods were sprayed at one week and two week intervals. The observed parameters were the number of pods infested with cocoa pod borer, pod rot and Helopeltis spp. at 4th - 14th weeks after first spray. From the observation, weekly biokaolin application showed the highest amount pods free from cocoa pod borer (33.97 %), followed by biweekly application (27.96 %), and plastic sleeving (19 %). Ten weeks after first spray, cocoa pod borer incidence was significantly reduced especially in weekly application. The percentage of pods free from pod rot were 81.92 %, 62.96 %, and 72.20 % for weekly spray, biweekly spray, and plastic sleeving, respectively. Pods being kept for 12 weeks in plastic sleeve endured the highest intensity of pod rot incidence. Biweekly biokaolin treatment was better in handling Helopeltis spp. attack. Besides reducing infestation of the main pests and diseases, biokaolin application also reduced the incidence of cherelle wilt to almost 40%. Those results gave the great expectation that biokaolin usage would significantly increase cacao yield, resulting in the increase of cacao farmer income. AbstrakKendala utama dalam upaya budidaya kakao adalah adanya serangan hama penggerek buah kakao (PBK), Conopomorpha cramerella (Snellen) dan hama kepik Helopeltis spp., serta serangan patogen penyebab busuk buah (Phythophtora palmivora). Sampai saat ini belum tersedia teknologi yang secara efisien mengendalikan ketiga-tiganya sekaligus. Peneltian ini bertujuan untuk mengembangkan teknologi yang ramah lingkungan untuk melindungi permukaan buah kakao. Percobaan dilakukan pada perkebunan kakao dengan tingkat serangan yang berat di Konawe, Sulawesi Tenggara. Dalam penelitian ini, penggunaan lapisan partikel kaolin yang diperkaya dengan mikroba entomopatogenik dibandingkan efektifitasnya dengan penyarungan menggunakan kantung plastik yang direkomendasikan selama ini. Buah kakao disemprot setiap interval satu minggu dan dua minggu sekali. Parameter yang diamati adalah jumlah buah terserang PBK, jumlah serangan busuk buah dan jumlah serangan Helopeltis spp. pada minggu keempat sampai dengan minggu ke-14 setelah penyemprotan pertama. Hasil pengamatan menunjukkan bahwa persentase tertinggi (33,97 %) buah kakao yang terbebas dari serangan PBK diperoleh pada plot dengan penyemprotan biokaolin setiap minggu, diikuti dengan penyemprotan setiap dua minggu (27,96 %), dan penyelubungan dengan kantung plastik (19,00 %). Pada minggu ke- 10 setelah penyemprotan pertama terjadi penurunan intensitas serangan PBK secara signifikan khususnya pada perlakuan setiap minggu. Persentase buah kakao yang terbebas dari penyakit busuk buah 81,92 %, 62,96 %, dan 72,20 %, secara berturutan untuk perlakuan penyemprotan setiap satu minggu,setiap dua minggu, dan penyarungan plastik. Pada minggu ke-12 buah kakao yang diberi perlakuan penyarungan mengalami peningkatan serangan busuk buah paling tinggi dibandingkan dengan perlakuan lainnya. Perlakuan penyemprotan setiap dua minggu memberikan perlindungan terbaik dari serangan Helopeltis spp. Hasil ini memberikan harapan besar bahwa aplikasi biokaolin sangat berpotensi meningkatan hasil panen petani kakao sehingga akan meningkatkan pendapatan petani.

Optimisasi dan pemurnian IAA yang dihasilkan Rhizobium sp. dalam medium serum lateks dengan suplementasi triptofan dari pupuk kandang Optimization and purification of IAA produced by Rhizobium sp. in latex serum media supplemented with tryptophan from chicken manure Irma KRESNAWATY; Syeda ANDANAWARIH; . SUHARYANTO; . TRI-PANJI
Menara Perkebunan Vol. 76 No. 2: 76 (2), 2008
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v76i2.83

Summary Concentrated latex effluent had not been economically utilized, consequently it had become source of environmental pollution and conflicts with surrounding community. Whereas, the concentrated latex effluent could be used as substrate for microbes growth media due to its high concentration of carbon and nitrogen. One of the economical benefits of growing Rhizobium sp. in this waste is the production of indole acetic acid (IAA) that can be used for plant promotion growth. The aims of this research were to get the optimal IAA production of Rhizobium sp. by optimizing its tryptophan supplementation through hydrolysis of chicken manure and to purify IAA produced using chromatographic method. The use of chicken manure directly caused the browning effect, therefore these experiments were carried out the variation of NaOH 2 N hydrolysis treatments to reduce the effect. Direct hydrolysis as the first media was obtained by mixing latex serum and manure, and then this mixture was hydrolyzed. Meanwhile, separated hydrolysis was done by adding water to manure, being hydrolyzed, and divided to become second and third media. The second media was made by mixing manure hydrolysate and latex serum directly, whereas in third media, hydrolisate was added with alum as coagulating agent. Rhizobium sp. was then inoculated to all media and incubated for 24, 48, and 72 hours in 27-30oC. IAA was analyzed by spectrophotometric method with Salkowsky reagent and Thin Layer Chromatography (TLC). IAA was then extracted with ethyl acetate and purified with silica gel column chromatography. The separated hydrolysis without coagulation (second media) produced the highest IAA concentration, that is 14.40 mg/mL, whereas IAA produced by direct hydrolysis (first media) was 14.13 mg/mL and 0.90 mg/mL for third media during 48 hours. The fractionation result for each mediums showed that the highest IAA distribution in first media was the 12th fraction (38.70%), meanwhile in second media was the 15th fraction (50.25%) and in the third media was the 13th fraction (26.16%). Ringkasan Limbah lateks pekat saat ini belum di-manfaatkan secara ekonomis, bahkan menjadi sumber pencemaran lingkungan dan konflik dengan masyarakat sekitarnya. Padahal limbah lateks pekat dapat digunakan sebagai substrat pertumbuhan mikroba karena memiliki kandungan karbon dan nitrogen yang cukup tinggi. Salah satu nilai ekonomis yang dapat diperoleh dengan ditumbuhkannya Rhizobium sp. pada limbah tersebut, yaitu dihasilkannya asam indol asetat (indol acetic acid/IAA) yang dapat digunakan untuk memacu pertumbuhan tanaman. Penelitian ini bertujuan memperoleh produksi IAA optimal yang dihasilkan Rhizobium sp. dengan asupan triptofan dari hidrolisis pupuk kandang dan memurnikan IAA yang dihasilkan tersebut dengan metode kromatografi. Penggunaan pupuk kandang secara langsung menyebabkan efek pen-cokelatan, maka dilakukan variasi perlakuan hidrolisis dengan NaOH 2 N untuk mengurangi efek tersebut. Hidrolisis langsung sebagai medium pertama diperoleh dengan mencampur serum lateks dan pupuk kandang, sedangkan hidrolisis terpisah dilakukan dengan menambah pupuk kandang dengan air, dan dibagi menjadi medium kedua dan ketiga. Medium kedua dibuat dengan cara langsung mencampur hidrolisat dan serum lateks, sedangkan pada medium ketiga, hidrolisat diendapkan dengan alum sebagai bahan pengendap. Kemudian ke dalam masing-masing medium diinokulasi Rhizobium sp. dan diinkubasi selama 24 ,48, dan 72 jam pada suhu 27-30oC. Analisis IAA dilakukan secara spektrofotometri dengan metode Salkowski dan Kromatografi Lapis Tipis (KLT). IAA diekstraksi menggunakan etil asetat dan dimurnikan dengan kromatografi kolom silika gel. Hidrolisis terpisah tanpa pengendapan (medium kedua) menghasilkan IAA tertinggi, yaitu 14,40 mg/mL, sedangkan hidrolis langsung (medium pertama) menghasilkan IAA sebesar 14,13 mg/mL dan medium ketiga sebesar 0,90 mg/mL selama 48 jam. Hasil fraksinasi untuk masing-masing medium menunjukkan sebaran IAA tertinggi pada medium pertama berada pada fraksi ke-12 (38,70%), sedangkan pada medium kedua pada fraksi ke-15 (50,25%), dan pada medium ketiga ialah fraksi ke-13 (26,16%).

Optimisasi produksi biogas dari limbah lateks cair pekat dengan penambahan logam Optimization of biogas production from concentrated-latex effluent with addition of metals Irma KRESNAWATY; I SUSANTI; . SISWANTO; . TRI-PANJI
Menara Perkebunan Vol. 76 No. 1: 76 (1), 2008
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v76i1.92

Summary The treatment of concentrated-latex effluent process applied in the field presently, has not obtain optimum additional benefits. Besides that, the technology using ponding system needs wide area and causes air pollution that such a way caused conflicts with society. The application concept of clean industry: reuse, reduction, recovery and recycling, makes the possibilities to convert the effluent to be usefull products. One of the alternative effluent process is by utilizing it as the source of renewable energy, that is in the form of biogas as an alternative energy. The preliminary research showed that the use of spontaneous latex skim coagulation, the addition of 1% manure as source of seed, and leaf biomass as the source of carbon could increase the biogas production. This research was carried out to optimize biogas production by adding metal ion and to observe the parameters which influenced every stage of biogas production. At the beginning of the process, pH showed increasing due to the hydrolysis process that generally occured in acid condition, but it remained stable (6.6-7.7) in the next steps, whereas, the VFA value as well as BOD value tended to increase. COD value had fluctuative inclination caused by the conversion of organic compounds to produce biogas and the hydrolysis process of leaf biomass to organic compounds that decom-posed to further biogas. The best result of biogas production was showed by addition of Fe3+ with optimum concentration 0.50 mg/L effluent.

Biosorpsi logam Zn oleh biomassa Saccharomyces cerevisiae *) Biosorption of Zn metal by Saccharomyces cerevisiae biomass Irma KRESNAWATY; . TRI-PANJI
Menara Perkebunan Vol. 75 No. 2: 75 (2), 2007
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v75i2.145

SummaryHeavy metal in waste water potentiallycauses environmental pollution. Generally,heavy metal pollutions come from metalplating, textile, latex-rubber goods, and otherindustries. The process of latex-rubber goodindustries uses heavy metal in the form ofZnO as accelerator for rubber vulcanizationprocess, so that Zn 2+ ion exists in wastewatereffluents in concentration as much as 300 ppm,whereas the maximum limit allowed is 2.5 ppm.The chemical way generally used to decreaseZn 2+ concentration in wastewater effluents isby adding bases, NaOH or Ca(OH) 2 until pHreached 11, hence this metal is precipitated asits hydroxide. However, the way is done, isvery high cost and has a risk of the emergencesecondary pollution caused by excess base. Analternative way to absorb Zn 2+ consideredinexpensive is by using biosorbent in the formof Saccharomyces cerevisiae biomass frombioethanol industrial waste. The research wasconducted using artificial wastewater withZn 2+ ion concentration of 300 ppm and the pHwas adjusted to the range between 3-7.Biosorption was conducted by addition of freeS. cerevisiae biomass as well as byimmobilized cells on filter paper. Observationwas carried out for Zn 2+ concentration aftercontact time of two and five hours. The resultsof the research indicated that free andimmobilized S. cerevisiae biomass couldabsorb Zn 2+ metal and decreased itsconcentration from 250-300 ppm to 20-50 ppm.The optimum contact time was reached at onehour, while optimum sorption process occurredat pH 5. At low concentration, less than20 ppm S. cerevisiae biomass absorbed lessZn 2+ The NaOH-treated biomass showed bettersorption capabilities compared to cells treatedby formaldehyde or heat treatments. Thecontinue experiment showed the high capacityof biomass treated with NaOH to absorb Zn 2+ ,until concentration 24,02- 47,95 ppm in thefirst sampling and 1,15-10,99 ppm in thesecond sampling. Combination adsorptionprocess using charcoal and zeolite couldadsorp remain concentration of Zn 2+ , so thatcould reached the limit concentration-allowed.RingkasanLogam berat di dalam air limbahmerupakan penyebab pencemaran lingkunganyang potensial. Pencemaran logam berat padaumumnya berasal dari industri penyepuhanlogam, tekstil, barang jadi lateks, serta industrilain. Pada proses industri barang jadi lateksdigunakan logam berat dalam bentuk ZnOsebagai akselerator proses vulkanisasi karet,sehingga ion Zn 2+ terbawa dalam air limbahindustri barang jadi dengan konsentrasimencapai 300 ppm, sedangkan ambang bataskonsentrasi yang diperbolehkan maksimaladalah 2,5 ppm. Cara kimia yang umum di-gunakan untuk menurunkan kandunganZn 2+ dalam air limbah adalah dengan caramenambahkan basa, umumnya NaOH atauCa(OH) 2 , sampai pH sekitar 11, sehinggalogam berat ini diendapkan sebagai hidroksida-nya. Namun demikian, cara ini sangat mahaldan beresiko munculnya pencemaran sekunderakibat kelebihan basa. Salah satu alternatifyang murah untuk penyerapan Zn 2+ adalahmenggunakan biosorben berupa biomassaSaccharomyces cerevisiae yang berasal darilimbah pabrik bioetanol.Penelitian dilakukan dengan mengguna-kan air limbah artifisial yang mengandung ionZn 2+ dengan konsentrasi 300 ppm. Limbahartifisial diatur pHnya antara 3-7. Biosorpsidilakukan dengan menambahkan biomassaS. cerevisiae bebas maupun yang diamobilisasidengan kertas saring. Pengamatan dilakukanterhadap kandungan Zn 2+ setelah waktu kontakdua dan lima jam. Hasil penelitian menunjuk-kan bahwa biomassa S. cerevisiae bebasmaupun amobil mampu menyerap logam Zn 2+dan menurunkan konsentrasinya dari 250-300 ppm menjadi 20-50 ppm. Waktu kontakoptimum dicapai setelah satu jam, sedangkanproses sorpsi optimum terjadi pada pH 5.Biomassa S. cerevisiae kurang efektifmenyerap logam Zn 2+ pada konsentrasi rendah,di bawah 20 ppm. Perlakuan biomassa meng-gunakan NaOH menunjukkan kemampuanpenyerapan yang lebih baik jika dibandingkandengan yang diperlakukan menggunakanformaldehida dan pemanasan. Percobaan padaaliran kontinyu yang menggunakan biomassayang diperlaukan menggunakan NaOH,menunjukkan bahwa limbah artifisial Zn 2+dapat diturunkan sampai konsentrasi 24,02-47,95 ppm pada sampling pertama, dan 1,15-10,99 ppm pada sampling kedua. Kombinasipenyerapan menggunakan arang aktif danzeolit dapat menyerap sisa Zn 2+ mencapai batasyang diperbolehkan.

Gliserolisis enzimatik CPO dengan lipase amobil untuk produksi diasil dan monoasil gliserol (Enzymatic glicerolysis of CPO using immobilized lipase for production of diacyl- and monoacyl glycerol) TRI - PANJI; Firda DIMAWARNITA; Irma KRESNAWATY; Susy SAADAH; Tri AMININGSIH; Mira MIRANTI
Menara Perkebunan Vol. 87 No. 1 (2019): 87 (1), 2019
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v87i1.321

CPO is one of the largest plantation commodities that has a lot of derrivative products, among others are DiAcyl Glycerol (DAG) and MonoAcyl Glycerol (MAG). These derivative products have much higher added value because these can serve as healthy oil that able to prevent fat accumulation in human body.The industry of the derivative products is not yet developed in Indonesia, among others are caused by underdeveloped technology of specific lipase enzyme for the production of DAG 1.3- glycerides, the stability and the activity of lipase enzyme need to be improved. This research was conducted with the aim to develop the production technology for 1.3-glycerides, developthe technology forlipase immobilization, develop the technology for CPO glycerolysis with immobilized lipase, and obtain the data composition of glycerolysis products. Lipase-producing fungi were isolated from tempeh, then cultured in a growth medium containing CPO. Lipase was then immobilized on severall solid support. Glycerolysis product composition was analyzed by Thin Layer Chromatography. The research results showed that the immobilization of lipases from Rhyzopus oryzae with adsorption techniques can be performed using zeolite, CaCO3, silica gel, and cow bones. The highest activity of immobilized lipase is on CaCO3as much as 99.46%, then on cow bones (91.56%), on zeolite (90.69%), andsilica gel (59.63%). The optimum condition of non immobillized lipase is pH 7 and temperature 30 °C, while immobilized lipase on CaCO3 is at pH 8 and temperature35 ° C. Lipase immobilized on zeolite is at pH 8 and temperature of 30 ° C, on cow bone is at pH 7 and temperature of 30° C, andon silica gel is at pH 8 and temperature of 30° C. The all immobilized lipases are more stable than the free enzyme since the first week of storage. The optimum time of DAG production by immobilized lipase on CaCO3 is 18 hours to produce DAG level of 34.49% of the substrate.[Keywords: enzymatic glycerolysis, lipase, DAG, MAG, enzyme immobilization] AbstrakCPO merupakan komoditas perkebunan yang memiliki banyak produk turunan, di antaranya Diasil Gliserol (DAG) dan Monoasil Gliserol(MAG). Produk turunan tersebut memiliki nilai jual yang tinggi karena dapat berfungsi sebagai minyak sehat dengan kemampuannya mencegah akumulasi lemak dalam tubuh. Industri produk turunan ini belum banyak berkembang di Indonesia karena belum berkembangnya teknologi produksienzim lipase spesifik 1,3 gliserida untuk produksi DAG, serta stabilitas dan aktivitas enzim lipase yang masih perlu ditingkatkan.Penelitian ini bertujuan untuk mengembangkan teknologi produksi lipase spesifik 1,3-gliserida, teknologi amobilisasi lipase, teknologi gliserolisis CPO dengan lipase amobil, dan memperoleh data komposisi produk gliserolisis. Fungi penghasil lipase diisolasi dari tempe atau oncom, kemudian dibiakkan dalam media tumbuh mengandung CPO. Lipase kemudian diamobilisasi dalam beebrapa padatan pendukung. Komposisi produk gliserolisis dianalisis dengan metode Kromatografi Lapis Tipis. Hasil penelitian menunjukkan bahwa amobilisasi enzim lipase Rhyzopus oryzaedengan teknik adsorpsi dapat dilakukan menggunakanzeolit, CaCO3, silika gel, dan tulang sapi. Aktivitas enzim tertinggi terdapat pada enzim yang diamobilisasi CaCO3sebesar 99,46%, kemudiantulang sapi 91,56%, zeolit 90,69%, dan silika gel 59,63%. Kondisi optimum lipase bebas ialah pH 7 dan temperatur 30 °C, sedangkan lipase teramobilpada CaCO3ialah pH 8temperatur 35 °C,lipase teramobil zeolit ialah pH 8 temperatur 30°C, lipase teramobil tulang sapi ialahpada pH 7 temperatur 30°C, dan lipase teramobilsilika gel ialah pH 8 temperatur 30 °C. Seluruh lipase teramobil lebih stabil dibandingkan enzim bebas sejak penyimpanan pada minggu pertama.Waktu optimum produksi DAG dengan lipase teramobil pada CaCO3ialah selama 18 jam menghasilkan kadar DAG sebesar 34,49% dan MAG 29,22% dari substratnya.[Kata kunci: gliserolisis enzimatik, lipase, DAG, MAG, amobilisasi enzim

Recent studies of synthetic antibody-based 3-MCPD determination technology Hasim MUNAWAR; Prima LUNA; Irma KRESNAWATY; Happy WIDIASTUTI
Menara Perkebunan Vol. 89 No. 1 (2021): 89 (1), 2021
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v89i1.402

3-Chloro-1,2-propanediol (3-MCPD) is classified by the International Agency for Research on Cancer as carcinogenic material. 3-MCPD will also become one of the European Union's requirements, proposing the maximum level of the 3-MCPD in palm oil until 2.5 ppm. Although the reported technologies GCMS and HPLC-FLD demonstrated high sensitivity and selectivity on 3-MCPD determination, those technologies invest in chemical and time-consuming sample preparation and analysis. Molecularly imprinted polymer (MIP), or a synthetic antibody, can be used to recognize 3-MCPD. MIP is more robust under extreme environments such as temperature and pH. This paper, therefore, aims to discuss the application of MIP on sample extraction and analysis to detect 3-MCPD. MIP is synthesized by polymerization of functional monomers surrounding 3-MCPD as a template. 3-MCPD is then removed from the MIP, leaving active cavities. Thus, these sites can either covalently or non-covalently rebind to 3-MCPD. Computational or empirical studies could investigate the composition of MIP. MIP can be manufactured as MIP-based solid phase extraction (MIPSPE) and MIP-based sensor. Both applications showed significant analytical parameters, such as recovery higher than 90% and detection limit lower than 2.5 ppm. Therefore, the application of MIP can be flexible for sample preparation and analysis on the 3-MCPD determination. MIP-based technology would be a prospective instrument to detect 3-MCPD. In the future, producing MIP on an industrial scale will be a challenge to monitor the 3-MCPD level in palm oil.

Molecular identification and phylogenetic analysis of Chlorella isolates from Indonesia using rbcL gene Fauziatul FITRIYAH; Yora FARAMITHA; Dini Astika SARI; Irma KRESNAWATY; Tri PANJI; Djoko SANTOSO
Menara Perkebunan Vol. 89 No. 1 (2021): 89 (1), 2021
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v89i1.408

Identifying the newly isolated species is crucial to establishing a reliable algal database with successful commercial applications for different biotechnological applications. Morphological identification does not give sufficient description, especially for tiny unicellular microalgae. The rbcL gene encodes the large unit of ribulose-1, 5-bisphosphate carboxylase /oxygenase (Rubisco) has been widely known for barcoding in plants and developed for microalgae molecular identification. In this study, we examined the local strains of green microalgae from Indonesia using the rbcL partial gene sequence to identify the strains. Green microalgae isolates originated from Yogyakarta, Serayu, Gondol, Ancol, Cilegon, and Teluk Jakarta were cultured in f/2 media and harvested for DNA extraction. The DNA extracted was proceeded to PCR using 1AB_rbcL primer pair to amplify the sequences of rbcL gene with target band located at 582 bp, followed by the sequencing of the PCR product was conducted. Molecular identification of local green microalgae isolates was successfully carried out using primers 1AB_rbcL with a genetic similarity of 99% toward identified species in the NCBI database. Among six isolates, TJ, G, S, C, and A isolates were identified as C. pyrenoidosa. Only CP isolate from Yogyakarta identified as C. sorokiniana. Nannochloropsis gaditana rbcL sequence was selected as an outgroup. The phylogenetic analysis indicated that the five isolates of Chlorella belong to one clade and clearly distinguished from C. sorokiniana isolate from Yogyakarta.

Potensi electronic nose 118 untuk mendeteksi penyakit busuk pangkal batang pada kelapa sawit Agustin Sri MULYATNI; Irma KRESNAWATY; Deden Dewantara ERIS; Tri PANJI; Wita KIMBERLY; Happy WIDIASTUTI; Priyono PRIYONO; Chotimah CHOTIMAH; Kuwat TRIYANA
Menara Perkebunan Vol. 90 No. 1 (2022): 90 (1), 2022
Publisher : INDONESIAN OIL PALM RESEARCH INSTITUTE

Show Abstract | Download Original | Original Source | Check in Google Scholar | DOI: 10.22302/iribb.jur.mp.v90i1.472

AbstractBasal stem rot (BSR) disease caused by Ganoderma sp. is a major disease in oil palm. One of the keys to successfully control BSR disease is to detect the pathogenic infections as early as possible. Early detection technique has been developed in this study was using volatile compounds sensors known as an electronic nose, specifically Electronic Nose 118. Plant samples were obtained from roots, stems, leaves, and soils of four plant categories, which were midly, moderately, and severely infected by Ganoderma, and healthy plants. The test results showed that Electronic Nose was able to record the profile of volatile organic compounds (VOC) produced by Ganoderma sp. The Linear Discriminant Analysis (LDA) results showed that the root and stem samples were differentiated in fairly high level of discrimination with values of 89.66% and 94.59% respectively, while for internal validation value were 98.18% and 89.18%. However, for leaf and soil samples, Electronic Nose 118 resulted in low discriminations. The test results show that Electronic Nose 118 can distinguish samples of roots and stems of healthy plant and Ganoderma-infected plant with a high accuracy.[Keywords: Ganoderma, linier discriminant analysis (LDA), pathogen infection, sensor, volatile organic compound] AbstrakPenyakit busuk pangkal batang (BPB) yang disebabkan oleh Ganoderma sp. merupakan penyakit utama pada kelapa sawit. Salah satu kunci keberhasilan pengendalian penyakit BPB adalah diketahuinya infeksi patogen sedini mungkin. Teknik deteksi dini yang saat ini dikembangkan dalam penelitian ini adalah menggunakan sensor senyawa volatil yang dikenal dengan electronic nose, khususnya Electronic Nose 118. Sampel tanaman diperoleh dari akar, batang, daun, dan tanah dari empat kondisi tanaman, yaitu tanaman yang terinfeksi Ganoderma ringan, sedang, berat dan tanaman sehat. Hasil pengujian menunjukkan bahwa profil senyawa organik volatil yang dihasilkan oleh infeksi Ganoderma sp. dapat ditangkap oleh Electronic Nose 118 dengan baik. Hasil analisis Linear Discriminat Analysis (LDA) menunjukkan bahwa sampel akar dan batang terbedakan dengan tingkat diskriminasi yang cukup tinggi dengan nilai secara berurutan yaitu 89,66% dan 94,59%, sedangkan untuk validasi internal masing-masing 98,18% dan 89,18%. Namun demikian, untuk sampel daun dan tanah, pengujian dengan Electronic Nose 118 menghasilkan tingkat diskriminasi yang rendah. Hasil pengujian menunjukkan Electronic Nose 118 dapat membedakan sampel akar dan batang dari tanaman sehat dan tanaman terserang Ganoderma dengan akurasi tinggi.[Kata kunci : Ganoderma, LDA, infeksi patogen, sensor, senyawa organik volatil]

Title

Found 30 Documents
Search

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Title Search

Found 30 Documents Search

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Abstract

Title

Found 30 Documents
Search